Sour gas
Much of the Habshan area is designated Red Zone because of hydrogen sulphide gas, so site-specific safety controls apply.
Habshan Gas · ATEX and IECEx
ATEX and IECEx Mobile Phone in Habshan Gas
Habshan, in south-western Abu Dhabi, is ADNOC Gas's largest processing complex, with five plants and 14 processing trains and 6.1 bscfd capacity. It yields sales gas, NGLs, condensate and sulphur, so Zone 1 areas cover process, compression and storage units. If you are specifying an ATEX and IECEx mobile phone for Habshan gas complex, this page covers the markings, the approvals and the current certification status of the IS-04Z1.
Pre-launch · certification in progress · Launching Q4 2026
Marking targetEx ib IIC T4Intrinsic safety, Zone 1 / 21 design target · certification in progress
AvailabilityQ4 2026via authorised distributors
Search topicATEX and IECEx
DeviceMobile Phone
RouteSpecification
WhereHabshan Gas
Short answer. The SAMS IS-04Z1 is the intrinsically safe smartphone covered here for Habshan gas complex: pre-launch, designed for Zone 1 and Zone 21 (marking target Ex ib IIC T4), with certification in progress and no certificate issued.
For the record, no certificate exists for the IS-04Z1 today. The programme is under way ahead of a Q4 2026 launch. A buyer's engineering review is separate from the certificate. Certification status. Place facts reviewed October 2026.
At a glance · ATEX and IECEx
Checklist: ATEX and IECEx mobile phone for Habshan gas complex
| Check | What to look for | IS-04Z1 today |
|---|---|---|
| Marking | II 2 G Ex ib IIC T4 on the rating plate | Design target; not yet marked |
| EU-type examination certificate | Notified body number and certificate ID | In progress with TÜV; not issued |
| IECEx certificate of conformity | Number listed on the IECEx online register | In progress; not issued |
| Where it applies | Habshan gas complex: Gas processing trains, NGL and condensate handling, Sulphur and acid-gas units | Classified by the site operator |
Product · Habshan Gas
The product behind this search: the SAMS IS-04Z1.
SAMS IS-04Z1
An intrinsically safe Android smartphone designed for Zone 1 and Zone 21 hazardous areas in Habshan Gas. It is pre-launch: IECEx, ATEX and NEC 500 certification is in progress ahead of the Q4 2026 launch.
- IP68 sealed
- 4,000 mAh battery
- 50 MP camera
- Android 16
- Zone 1 / Zone 21 design target
The site · Habshan gas complex
Habshan gas complex at a glance: who is there, what is classified
A short profile of the site and the kinds of classified area that matter for portable equipment.
Operators and companies on site
- ADNOC Gas
Classified areas to expect
- Gas processing trains
- NGL and condensate handling
- Sulphur and acid-gas units
- Gas pipelines
Local conditions · Habshan gas complex
Conditions in Habshan gas complex that affect handheld equipment
Pipelines
Two pipelines of over 200 km link Habshan with Das Island, and the Habshan-Fujairah crude pipeline starts here.
Field notes · Habshan gas complex
More about Habshan gas complex that matters for portable equipment
Habshan gas complex: background
Pipeline construction began in March 2008 and finished in March 2011; it became operational in June 2012, so its pump and metering stations are of 2010s vintage.
Habshan gas complex: rules and approvals
UAE handsets need type approval from the Telecommunications and Digital Government Regulatory Authority, which also required advanced mobile location testing for cell phones.
Habshan gas complex: industry on the ground
A large part of the Habshan area is marked as a Red Zone because hydrogen sulphide gas is present, so site entry rules and gas-safety practice are a key planning point for any visit.
Habshan gas complex: infrastructure
The Habshan to Fujairah crude pipeline is 406 km long, has a 48-inch diameter and a capacity of 1.5 million barrels a day.
The term · ATEX and IECEx
What “ATEX and IECEx” means for a smartphone
ATEX is the European legal framework for equipment used in explosive atmospheres (Directive 2014/34/EU). IECEx is the international certification scheme built on the IEC 60079 standards. Buyers outside Europe often ask for both: an IECEx certificate is the technical evidence most national regimes build on, while ATEX is the legal route into the European market.
For the IS-04Z1 both routes are in progress with TÜV in Germany and neither certificate has been issued. The marking target is II 2 G Ex ib IIC T4: equipment Group II (surface industry), Category 2 (Zone 1 gas), protection concept ib (intrinsic safety), gas group IIC and temperature class T4.
In Habshan gas complex. Habshan is ADNOC Gas's largest processing complex, so a reviewer would look for certificate numbers, markings and schedules of conditions for devices going into Zone 1 process, compression and storage units. A dual ATEX and IECEx route helps international contractors on turnaround projects. The IS-04Z1 certification is in progress.
The route · specification
Specifying an ATEX and IECEx mobile phone for Habshan Gas
A short checklist for anyone writing or reviewing the specification, with the IS-04Z1 status against each point.
Check on the paper
- Marking
- Equipment group, category, protection concept, gas group and temperature class, matched to the area drawing.
- Certificate and schedule
- A certificate number, issuing body and the schedule of conditions, not a brochure claim.
- Standards edition
- The IEC 60079 or national standard edition the certificate was issued against.
Check for the IS-04Z1
- Marking target
- II 2 G Ex ib IIC T4: a target, not yet a certificate.
- Certificate status
- IECEx, ATEX, UKEX and NEC 500 in progress; none issued.
- Operator approval
- Separate from the certificate and handled with the site operator.
Questions · Habshan Gas
Frequently asked questions
Can we buy an ATEX and IECEx mobile phone in Habshan Gas today?
Not today. Until the certificates are issued the IS-04Z1 stays out of classified areas, and until launch there is nothing to purchase. You can ask for the datasheet and the certification schedule, or book a safe-area evaluation unit.
What does an ATEX and IECEx mobile phone in Habshan Gas cost?
SAMS has not published a price. Any figure you are offered for an uncertified Ex phone should be treated with caution; written indicative pricing is available for a defined quantity and site.
Is the IS-04Z1 ATEX and IECEx certified?
Not yet. Both routes are in progress with TÜV in Germany and no certificate has been issued. Any listing that says otherwise is wrong.
Which areas at Habshan gas complex would use it?
Likely candidates are gas processing trains, ngl and condensate handling, sulphur and acid-gas units, gas pipelines. Which areas are classified, and to what zone, is set by the site operator's own area classification drawings.
Is intrinsically safe the same as explosion proof?
Not exactly. Explosion proof is a broad everyday term; intrinsic safety is one protection concept, which limits energy so ignition cannot occur. Flameproof (Ex d) is a different concept that contains an explosion. The IS-04Z1 is intrinsically safe by design.
How far does the Habshan to Fujairah pipeline run?
About 406 km, with a 48-inch diameter and a capacity of 1.5 million barrels a day, passing east of Abu Dhabi city, through Sweihan and west of Al Ain. Pumping and metering stations along it have their own classified areas, set by the operator.
Do Habshan sites have their own contractor rules?
Yes. As a controlled oil and gas area with worker camps, access is managed by the operator, normally through registered contractors with induction and permit procedures. Confirm current requirements for portable electronic devices and gas detection with the operator's HSE team.
What is the Red Zone at Habshan and does it affect handhelds?
Much of the Habshan area is designated Red Zone because of hydrogen sulphide, so site-specific safety controls apply. These are separate from explosion protection, and are set by ADNOC Gas. Ask the operator what is required for a device and for personnel in those areas.
Related guides
Keep exploring
Other guides for Habshan Gas, other places in United Arab Emirates, and the pages behind them.
Explosion-Proof Mobile Phone in Habshan GasSame place, different guide
Rugged Mobile Phone Distributor in Habshan GasSame place, different guide
Ex-Proof Mobile Phone in Habshan GasSame place, different guide
IECEx Mobile Phone Distributor in Habshan GasSame place, different guide
Intrinsically Safe Mobile Phone Distributor in Habshan GasSame place, different guide
Hazardous Area Mobile Phone in Habshan GasSame place, different guide
ATEX and IECEx Mobile Phone Distributor in SharjahElsewhere in United Arab Emirates
ATEX and IECEx Mobile Phone Distributor in Ras Al KhaimahElsewhere in United Arab Emirates
ATEX and IECEx Mobile Phone Distributor in Umm Al Nar RefineryElsewhere in United Arab Emirates
ATEX and IECEx Mobile Phone Distributor in Abu DhabiElsewhere in United Arab Emirates
United Arab Emirates market guideCertification route and regulators
All guides for United Arab EmiratesEvery route we cover
Certification statusWhat is in progress
Enquiry · Habshan gas complex
Ask about the IS-04Z1 for Habshan gas complex, United Arab Emirates
Tell us what you need to equip and where. The SAMS team answers by email with the datasheet and where each certification route stands.
Enquiry · Habshan gas complex
Launching Q4 2026
Planning for Habshan Gas?
Name the site and the operator and we will send what is available before launch.