A Zone 1 and Zone 21 handset for Malaysian crews: process and maintenance technicians at Pengerang and Kertih, LNG operators at Bintulu, offshore production staff off Miri and Kimanis, and the safety and telecoms people who issue their equipment. This page explains what to look for in an intrinsically safe cell phone for Malaysia, and where the IS-04Z1 stands against that list today.
Pre-launch · certification in progress · Launching Q4 2026
Short answer. The SAMS IS-04Z1 is the intrinsically safe smartphone covered here for Malaysia: pre-launch, designed for Zone 1 and Zone 21 (marking target Ex ib IIC T4), with certification in progress and no certificate issued.
For the record, no certificate exists for the IS-04Z1 today. The programme is under way ahead of a Q4 2026 launch. An operator's own vendor approval is a separate step. Certification status. Place facts reviewed October 2026.
| Check | What to look for | IS-04Z1 today |
|---|---|---|
| Level of protection | ia, ib or ic matched to the zone | ib, for Zone 1 |
| Entity parameters | Uo, Io and Po within the device limits | Published with the certificate |
| Accessories | Chargers and cases certified with the device | Defined at certification |
| Where it applies | Malaysia: Pengerang, Johor, Kertih, Terengganu, Gebeng, Pahang | Classified by the site operator |
An intrinsically safe Android smartphone designed for Zone 1 and Zone 21 hazardous areas in Malaysia. It is pre-launch: IECEx, ATEX and NEC 500 certification is in progress ahead of the Q4 2026 launch.
The classified areas, operators and sites below are the ones covered in the SAMS Malaysia market guide.
The Malaysian Communications and Multimedia Commission (MCMC), based in Cyberjaya, regulates communications under the Communications and Multimedia Act 1998, so radio and mobile-device rules sit with a different body from Ex rules.
Electrical and electronic products, petroleum products, LNG, chemicals and palm-oil-based manufactures are among the main exports, so processing sites range from petrochemical units to palm-oil mills.
Energy supply is regulated by the Energy Commission (Suruhanjaya Tenaga) and the Department of Electricity and Gas Supply, under laws that include the 1974 Petroleum Development Act and the 1993 Gas Supply Acts.
PETRONAS describes its Pengerang Integrated Complex in Johor as one of Southeast Asia's largest integrated petrochemical facilities, valued at USD 27 billion and located within the Pengerang Integrated Petroleum Complex.
Intrinsic safety limits the electrical and thermal energy in a circuit so that neither a spark nor a hot surface can ignite a gas or dust atmosphere, even when a fault occurs. The ib level, used for Zone 1, tolerates one fault. It is the usual way to make a handheld device that a worker carries continuously through a hazardous area.
The IS-04Z1 is designed on this principle for Zone 1 and Zone 21 (marking target II 2 G Ex ib IIC T4). Intrinsic safety is a design basis, not a certificate: certification is in progress and none has been issued yet.
In Malaysia. Technicians at Kertih, Pengerang and Bintulu make long outdoor rounds and turnaround inspections, and offshore crews spend a hitch on platforms reached by helicopter or boat. An intrinsically safe handheld lets one device carry the camera, GNSS and work-order app into classified ground, and nothing can be replaced mid-hitch if it is not practical to carry spares.
A short checklist for anyone writing or reviewing the specification, with the IS-04Z1 status against each point.
Not today. Until the certificates are issued the IS-04Z1 stays out of classified areas, and until launch there is nothing to purchase. You can ask for the datasheet and the certification schedule, or book a safe-area evaluation unit.
There is no list price yet. SAMS gives indicative pre-launch pricing in writing, against a stated quantity and site, and does not commit to a lead time before certification completes.
The circuits are designed to limit energy so a spark or hot surface cannot ignite a gas or dust atmosphere, even with one fault (level ib, Zone 1). Certification of that design is in progress.
The market guide for Malaysia covers Pengerang, Johor, Kertih, Terengganu, Gebeng, Pahang, Bintulu, Sarawak, among others. Site-level pages are linked below.
Not exactly. Explosion proof is a broad everyday term; intrinsic safety is one protection concept, which limits energy so ignition cannot occur. Flameproof (Ex d) is a different concept that contains an explosion. The IS-04Z1 is intrinsically safe by design.
Malaysia is hot and humid, so check the stated operating temperature range, ingress protection rating and battery behaviour at the top of that range. Offshore and coastal sites also add salt-laden air, which makes sealed connectors and charging contacts worth checking.
Petronas and its operating companies typically apply their own site procedures on top of national law, including permit-to-work and device registration. Requirements vary by facility and contractor, so ask the site HSE office for its current device and induction rules.
Radio equipment is regulated separately from explosion protection. The programme lists MCMC certification through SIRIM QAS for the communications side, alongside IECEx for the hazardous area side, and both are in progress. Check with your supplier and the site operator which evidence your site requires before enrolling any device.
Related guides for Malaysia and for Malaysia.
Send the site, zone and gas group and roughly how many handsets. We reply by email with the datasheet and the certification schedule.
Tell us the zone, gas group and operator. We will send the datasheet and the certification schedule.
